CONTOURE 65,000 BTU RV Tankless Propane Water Heater

1. پیژندنه

Thank you for choosing the CONTOURE 65,000 BTU RV Tankless Propane Water Heater. This manual provides essential information for the safe and efficient installation, operation, and maintenance of your new water heater. Please read all instructions carefully before attempting to install or operate the unit. Retain this manual for future reference.

This tankless water heater is designed to provide on-demand hot water for recreational vehicles and campers, offering high-flow performance and a dual outlet capability for multiple fixtures.

2. د خوندیتوب معلومات

خبرداری: ناسم نصب، تنظیم، بدلون، خدمت، یا ساتنه کولی شي د ملکیت زیان، ټپي کیدو یا مړینې لامل شي. د دې تجهیزاتو نصب یا خدمت کولو دمخه د نصب کولو ، عملیاتي ، او ساتنې لارښوونې په بشپړ ډول ولولئ.

• Ensure all gas and water connections are properly sealed and leak-free.
• د اوبو ګرمولو ځای ته نږدې د اور اخیستونکي مواد مه ساتئ.
• Verify proper ventilation and exhaust for propane combustion.
• Always turn off the propane supply and disconnect electrical power before performing any service or maintenance.
• This appliance must be installed by a qualified service technician in accordance with all local codes and ordinances.

3. ترتیب او نصب کول

The CONTOURE RV Tankless Propane Water Heater is designed for easy retrofit into standard 15x15 inch cutouts. Follow these steps for proper installation:

3.1. خلاصول او معاینه کول

Carefully remove the water heater from its packaging. Inspect the unit for any signs of damage during transit. Report any damage to your supplier immediately.

3.2. د واحد نصبول

Position the water heater in the designated cutout. Ensure the unit is level and securely fastened using appropriate mounting hardware. The black access door should face outwards.

شکل 1: مخکی view of the CONTOURE RV Tankless Water Heater with its black access door, showing the 'CONTOURE' logo and 'HOT' indicator.

3.3. د نلدوانۍ نښلول

1. Connect the cold water inlet to the designated port on the water heater.
2. Connect the hot water outlet to your RV's hot water distribution system.
3. Ensure all water connections are tight and use appropriate RV-grade plumbing fittings.
4. Open all hot water faucets in the RV to purge air from the system once water supply is connected.

3.4. د ګازو نښلول

1. Connect the propane gas supply line to the gas inlet on the water heater.
2. Use only approved gas fittings and ensure all connections are leak-tested with a suitable leak detection solution.
3. Verify that the propane pressure is within the specified operating range for the appliance.

3.5. بریښنایی ارتباطات

Connect the 12V DC power supply to the water heater's electrical terminals. Ensure correct polarity. The unit requires a stable 12V DC power source for operation of its control board and fan.

شکل 2: داخلي view of the water heater, illustrating the copper heat exchanger, gas valve, and various electrical connections. This view is crucial for understanding plumbing and wiring during installation.

3.6. د پیل پیل

1. After all connections are made and checked, open the propane supply valve.
2. Turn on the 12V DC power to the unit.
3. Open a hot water faucet in the RV. The water heater should ignite and begin producing hot water.
4. Allow water to run for a few minutes to ensure all air is purged from the gas line and water system.

4. عملیاتي لارښوونې

The CONTOURE Tankless Water Heater operates on demand, meaning it only heats water when a hot water faucet is opened.

4.1. آن/بندول

The unit is typically controlled by a switch located on the RV's control panel or directly on the water heater's internal control board (if accessible). Ensure the 12V DC power is supplied to the unit for operation.

۵.۲. د ګرمو اوبو رسول

To obtain hot water, simply open any hot water faucet in your RV. The water heater will sense the water flow and automatically ignite to heat the water to the desired temperature. Close the faucet to stop the heating process.

4.3. Dual Outlet Performance

This model supports dual outlet usage, allowing simultaneous hot water delivery to two fixtures. Performance may vary depending on the flow rate and desired temperature at each fixture.

4.4. Cold Weather Operation (Winterization)

During cold weather, it is crucial to properly winterize the water heater to prevent freezing and damage. Refer to the Maintenance section for detailed winterization procedures.

5. ساتنه

منظم ساتنه ستاسو د اوبو ګرمولو ماشین اوږد عمر او مؤثر عملیات تضمینوي.

5.1. بهرنۍ پاکول

Clean the exterior access door and vents periodically with a mild detergent and soft cloth. Ensure vents are clear of obstructions.

5.2. Gas Line Inspection

Periodically inspect all gas connections and lines for leaks or damage. Use a leak detection solution to check for gas leaks at connections.

5.3. Water System Descaling

Depending on water hardness, mineral deposits can accumulate in the heat exchanger. Consult a qualified RV technician for periodic descaling to maintain efficiency. The frequency depends on water quality and usage.

5.4. Winterization Procedure

Before storing your RV in freezing temperatures, the water heater must be winterized:

1. Turn off the propane supply and disconnect the 12V DC power to the water heater.
2. Drain all water from the RV's plumbing system, including the water heater. Open the drain valve on the water heater (if present) or disconnect the cold water inlet to allow drainage.
3. Ensure no water remains in the unit's heat exchanger or pipes.
4. If using RV antifreeze, ensure it circulates through the hot water lines connected to the water heater.

6. ستونزه حل کول

This section provides solutions for common issues. If problems persist, contact a qualified service technician.

7. مشخصات

8. د تضمین معلومات

This CONTOURE product is covered by a limited warranty. For specific warranty terms, conditions, and registration details, please refer to the warranty card included with your product or visit the official CONTOURE webسایټ. د تضمین ادعاوو لپاره د پیرود ثبوت وساتئ.

9. د پیرودونکي ملاتړ

For technical assistance, parts, or service inquiries, please contact CONTOURE customer support. You can find contact information on the CONTOURE webسایټ یا ستاسو د محصول پرچون پلورونکي له لارې.

لیدنه وکړئ CONTOURE Store for more information on our products.