پیژندنه
This manual provides detailed instructions for the safe installation, operation, and maintenance of the White Rodgers 36E38-301 Gas Valve. This valve is specifically designed for natural gas applications only and operates on a 24 VAC power supply. It features a redundant (pilot) valve design with specified outlet pressures for optimal performance in compatible heating systems.
د خوندیتوب مهمې لارښوونې
WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause property damage, personal injury, or loss of life. Read these instructions thoroughly before installing or servicing this equipment.
- نصب او خدمت باید د وړ نصب کونکي، خدماتو ادارې، یا ګاز عرضه کوونکي لخوا ترسره شي.
- Disconnect the electrical power supply before making any wiring connections to prevent electrical shock or equipment damage.
- Ensure all gas connections are tight and leak-free before operating the valve. Use a non-corrosive leak detection solution.
- Do not use this valve with any gas type other than natural gas.
- Always follow local codes and regulations governing gas appliance installation and safety.
د محصول ځانګړتیاوې
- ماډل: 36E38-301
- د ګاز ډول: یوازې طبیعي ګاز
- والیtage: 24 VAC
- د والو ډول: Redundant (Pilot) Valve
- د مزو تړاو: 1/2 انچه
- د آوټ لیټ پیوستون: 3/4 انچه
- Step Outlet Pressure: 1.2 انچه WC
- Full Outlet Pressure: 3.5 انچه WC
- خارجي پای: سټینلیس سټیل
- د بندرونو شمیر: 2
- موافقت: ANSI Z21.24
تنظیم او نصب کول
Note: Installation should only be performed by a qualified technician.
- د نصب کولو دمخه چک:
- Verify that the gas valve model (36E38-301) matches the system requirements for natural gas and 24 VAC.
- Ensure the gas supply is turned off at the main valve.
- Disconnect electrical power to the appliance.
- پورته کول:
- Mount the valve securely in the correct orientation as specified by the appliance manufacturer.
- Ensure adequate clearance for wiring and gas piping.
- د ګازو پایپ اتصالونه:
- Apply pipe sealant suitable for natural gas to all male pipe threads. Do not apply sealant to the first two threads.
- Connect the gas supply line to the inlet port (1/2").
- Connect the appliance manifold to the outlet port (3/4").
- Tighten all connections firmly but do not overtighten.
- بریښنایی تارونه:
- Connect the 24 VAC power supply wires to the appropriate terminals on the valve as per the appliance wiring diagram.
- ډاډ ترلاسه کړئ چې ټولې اړیکې خوندي او موصلې دي.
- د لیک ازموینه:
- د ګاز اصلي عمده عرضه بنده کړئ.
- Apply a non-corrosive leak detection solution to all gas connections.
- Bubbles indicate a leak. Tighten connections or reapply sealant as necessary.
- هیڅکله د ګاز لیکونو چک کولو لپاره خلاص لمبه مه کاروئ.
- لومړنی پیل:
- Restore electrical power to the appliance.
- Follow the appliance manufacturer's instructions for initial startup and pilot lighting procedures.
No relevant official product videos for installation from a 'Seller' were found in the provided data.
عملیاتي لارښوونې
The White Rodgers 36E38-301 Gas Valve operates in conjunction with your appliance's control system. It is designed to regulate the flow of natural gas to the burner based on demand.
- نورمال عملیات: When the appliance's control system calls for heat, it sends a 24 VAC signal to the gas valve.
- Pilot Ignition: The redundant pilot valve opens first, allowing gas to flow to the pilot burner for ignition.
- Main Burner Ignition: Once the pilot is established and sensed by the control system, the main valve opens, allowing gas to flow to the main burner for heating.
- بندول: When the heat demand is satisfied, the 24 VAC signal is removed, and the gas valve closes, shutting off the gas supply to both the pilot and main burners.
Important: Do not attempt to manually operate the valve unless specifically instructed by a qualified technician during troubleshooting or service procedures.
No relevant official product videos for operation from a 'Seller' were found in the provided data.
د ساتنې لارښوونې
The White Rodgers 36E38-301 Gas Valve is designed for reliable operation with minimal maintenance. However, periodic checks are recommended to ensure continued safe and efficient performance.
- کلنۍ معاینه: هر کال یو وړ تخنیکر د ګاز والو او د ګازو ټولو اتصالونو د خرابوالي، زنګ وهلو یا لیکیدو نښو لپاره معاینه کړي.
- پاکول: Keep the area around the gas valve clean and free from dust, debris, and obstructions. Do not use harsh chemicals or abrasive cleaners on the valve body.
- د لیک چکونه: Periodically perform a leak check on all gas connections using a non-corrosive leak detection solution.
- Pilot Flame Inspection: If applicable to your appliance, ensure the pilot flame is stable, blue, and properly impinging on the thermocouple/thermopile. Refer to your appliance manual for specific pilot adjustment procedures.
Caution: Do not attempt to disassemble or repair the gas valve. If the valve is found to be faulty, it must be replaced by a qualified technician.
No relevant official product videos for maintenance from a 'Seller' were found in the provided data.
د عامو ستونزو حل کول
دا برخه د عامو ستونزو لپاره لارښوونې چمتو کوي. د پیچلو ستونزو لپاره یا که تاسو ډاډه نه یاست، تل د وړ خدماتو تخنیکین سره اړیکه ونیسئ.
| ستونزه | احتمالي لامل | د حل لاره |
|---|---|---|
| No gas flow to burner | Gas supply off; Electrical power off; Faulty thermostat/control; Faulty gas valve | Check main gas supply; Check electrical breaker/fuse; Verify thermostat setting; Contact technician for valve inspection or replacement. |
| Pilot light won't stay lit | Dirty pilot orifice; Faulty thermocouple/thermopile; Low gas pressure | Clean pilot orifice; Replace thermocouple/thermopile; Contact gas supplier or technician for pressure check. |
| د ګاز بوی کشف شو | د ګاز لیک | Immediately turn off gas supply and ventilate area. Do not operate electrical switches or create sparks. Contact your gas company and a qualified technician immediately. |
د محصول مشخصات
- د ماډل شمیره: 36E38-301
- نښه: سپین - راډګرونه
- جوړونکی: سپینې راډرز
- د ګاز ډول: یوازې طبیعي ګاز
- والیtage: 24 VAC
- د والو ډول: Redundant (Pilot)
- د مزو تړاو: 1/2 انچه
- د آوټ لیټ پیوستون: 3/4 انچه
- Step Outlet Pressure: 1.2 انچه WC
- Full Outlet Pressure: 3.5 انچه WC
- خارجي پای: سټینلیس سټیل
- د بندرونو شمیر: 2
- موافقت: ANSI Z21.24
- د شتون لومړۍ نیټه: د اپریل 27، 2007
یادونه: مشخصات پرته له خبرتیا بدلیږي.
تضمین معلومات او تخنیکي ملاتړ
Specific warranty details for the White Rodgers 36E38-301 Gas Valve are typically provided with the product packaging or can be obtained directly from the manufacturer or an authorized distributor.
For technical support, service, or warranty claims, please contact White-Rodgers customer service or an authorized service center.
د جوړونکي د اړیکو معلومات:
- نښه: سپین - راډګرونه
- Webسایټ: Emerson - White-Rodgers
Please refer to the product packaging or the manufacturer's webد اړیکو د تازه جزئیاتو او ملاتړ سرچینو لپاره سایټ.
No relevant official product videos for warranty or support from a 'Seller' were found in the provided data.
